img

QQ群聊

img

官方微信

  • CN 62-1112/TF 
  • ISSN 1005-2518 
  • 创刊于1988年
高级检索
冶炼技术与装备研发

某难处理金矿热压氧化渣预处理试验研究

  • 丁文涛 ,
  • 蔡创开 ,
  • 郭金溢 ,
  • 许晓阳
展开
  • 厦门紫金矿冶技术有限公司,福建  厦门   361101
丁文涛(1988-),男,江西丰城人,助理工程师,从事贵金属湿法冶金研究工作。ding_wentao@zjky.cn

收稿日期: 2015-11-06

  修回日期: 2015-12-14

  网络出版日期: 2016-04-05

Recovery of Gold and Silver from Pressure Oxidative Slag of Refractory Gold Ore

  • DING Wentao ,
  • CAI Chuangkai ,
  • GUO Jinyi ,
  • XU Xiaoyang
Expand
  • Xiamen Zijin Mining & Metallurgy Technology Co.,Ltd.,Xiamen   361101,Fujian,China

Received date: 2015-11-06

  Revised date: 2015-12-14

  Online published: 2016-04-05

摘要

高铜难处理金矿经酸性热压氧化后,铜基本被浸出进入溶液中,消除了铜对氰化过程的影响,而银在热压处理过程中易与生成的黄钾铁矾相结合,生成难处理的银铁矾[AgFe3(SO42(OH)6],在随后的常规氰化试验中,金回收率达99%以上,但银回收率不足10%。针对银回收率低的问题,系统考察了矿浆浓度、NaCN浓度、石灰用量、预处理温度和时间、氰化时间及炭密度等因素对金、银浸出率的影响,进而确定了最佳浸出条件。试验结果表明:在85~90 ℃、矿浆浓度为40%、石灰用量为40 kg/t的条件下,对氧化渣进行碱性预处理,随后在NaCN用量为0.10%的条件下浸出8 h,银回收率得到大幅提高(达到85%),金浸出率也保持在99%以上。

本文引用格式

丁文涛 , 蔡创开 , 郭金溢 , 许晓阳 . 某难处理金矿热压氧化渣预处理试验研究[J]. 黄金科学技术, 2016 , 24(1) : 108 -112 . DOI: 10.11872/j.issn.1005-2518.2016.01.108

Abstract

After acidic pressure oxidation of refractory gold ore containing copper,copper were basically leached into the solution and eliminated the influence  on cyanide process,while silver in the pressure oxidation process could combine with jarosite to generate [AgFe3(SO4)2(OH)6].The gold and silver recovery rate reached respectively over 99% and less than 10% in conventional cyanide process.This paper investigated the effect of pulp density,dosage of sodium cyanide and lime,pretreatment temperature and time,cyanide time and carbon density to leaching rate for gold and silver,finally the optimum leaching condition was determined.The silver recovery was improved substantially after silver pretreatment on the condition of 85~90 ℃,pulp concentration of  40% and lime dosage of  40 kg/t which achieved about 85%,meanwhile,the gold leaching rate also remain above 99%.

参考文献

[1] 孙留根,袁朝新,王云,等.难处理金矿提金的现状及发展趋势[J].有色金属(冶炼部分),2015,(4):38-43.
[2] 张文波.加压氧化浸出工艺的机理研究[J].黄金科学技术,2012,19(5):40-44.
[3] 崔永霞,沈艳.难处理金矿石提炼技术研究进展[J].黄金科学技术,2007,15(3):53-57.
[4] 黄凌.难处理金精矿3种预处理分析[J].现代矿业,2013,(6):82-84.
[5] 王帅,李超,李宏煦.难浸金矿预处理技术及其研究进展[J].黄金科学技术,2014,22(4):129-134.
[6] 余建文,高鹏,韩跃新,等.难浸金矿预处理方法的新进展[J].矿冶,2013,22(2):59-62.
[7] 徐名特,孟德铭,代淑娟.难选金预处理工艺研究现状[J].有色矿岩,2014,30(2):18-22.
[8] 陈红轶,姚国成.难浸金矿预处理技术的现状及发展方向[J].金属矿山,2009,(9):81-83.
[9] 金世斌,石吉友,鲁玉春,等.国外难处理金矿热压氧化工艺条件分析[J].黄金,2013,34(6):52-56.
[10] 许晓阳,蔡创开,丁文涛.某难处理金矿热压预氧化—氰化工艺研究[J].黄金科学技术,2014,22(4):135-138.
[11] Bolorunduro S A,Dreisinger D B,Weert G V.Fundamental study of silver deportment during the pressure oxidation of sulphide ores and concentrates[J].Minerals Engineering,2003,16(8):695-708.
[12] 黄怀国.难处理金精矿的酸性热压预氧化研究[J].矿冶工程,2007,27(4):42-45.
[13] 李大江.含砷金精矿的酸性热压氧化预处理试验[J].有色金属(冶炼部分),2011,(8):28-31.
[14] Kasaini H,Kasongo K,Naude N,et al.Enhanced leachability of gold and silver in cyanide media:Effect of alkaline pre- treatment of jarosite minerals[J].Minerals Engineering,2008,21(15):1075-1082.
[15] Bolorunduro S A,Dreisinger D B,Weert G V.Zinc and silver recoveries from zinc-lead-iron complex sulphides by press-ureoxidation[J].Minerals Engineering,2013,16(4):375-389.
[16] Liang D Q,Wang J K,Wang Y H,et al.Recovery of silver and zinc by acid pressure oxidative leaching of silver-bearing low-grade complex sulfide ores[J].International
Journal of Mineral Processing,2008,89(1/4):60-64.
[17] Jia Y F,Steele C J,Hayward I P,et al.Mechanism of adsorption of gold and silver species on activated carbons[J].Carbon,1998,36(9):1299-1308.
[18] 张云,杨建元,胡承祥.高含量银对活性炭从硫脲溶液中吸附金的影响[J].黄金,2000,21(3):30-33.

文章导航

/