img

QQ群聊

img

官方微信

高级检索

黄金科学技术 ›› 2017, Vol. 25 ›› Issue (2): 76-82.doi: 10.11872/j.issn.1005-2518.2017.02.076

• 采选技术与矿山管理 • 上一篇    下一篇

分级加载条件下深部灰岩蠕变试验及模型

肖伟晶1,2,陈辰1,李永欣1,王晓军1,2*,曹世荣1,韩建文1   

  1. 1.江西理工大学资源与环境工程学院,江西  赣州   341000;
    2.江西省矿业工程重点实验室,江西  赣州   341000
  • 收稿日期:2016-08-26 修回日期:2017-01-22 出版日期:2017-04-28 发布日期:2017-05-12
  • 通讯作者: 王晓军(1979-),男,山西晋中人,博士,副教授,从事矿山工程岩体稳定性分析与控制等方面的研究与教学工作。xiaojun7903@126.com
  • 作者简介:肖伟晶(1991-),男,江西高安人,硕士研究生,从事矿山工程岩体稳定性分析与控制等方面的研究工作。921046160@qq.com
  • 基金资助:

    国家自然科学基金项目“堆浸应力路径与化学置换过程散体矿堆力学特性弱化机制研究”(编号:51564012)和江西省科技支撑计划项目“急倾斜薄脉群钨矿床开采岩体失稳控制技术集成与示范”(编号:20141BBE50005)联合资助

Creep Experiment and Model of Deep Limestone Under Step Loading

XIAO Weijing1,2,CHEN Chen1,LI Yongxin1,WANG Xiaojun1,2,CAO Shirong1,HAN Jianwen1   

  1. 1.Faculty of Resource and Environmental Engineering,Jiangxi University of Science and Technology,Ganzhou    341000,Jiangxi,China;
    2.Jiangxi Key Laboratory of Mining Engineering,Ganzhou    341000,Jiangxi,China
  • Received:2016-08-26 Revised:2017-01-22 Online:2017-04-28 Published:2017-05-12

摘要:

通过对矿山深部灰岩开展分级加载单轴蠕变试验,获取了不同应力水平下轴向和径向蠕应变,基于试验结果,分析各分级应力水平下轴向蠕应变、径向蠕应变和体应变的变化规律,研究轴向和径向蠕应变与各分级总应变的比值关系,并将该比值依次定义为蠕变效应比Kz、Kh,二者之差为Kh-z。研究发现:随着应力水平的提高,各分级轴向和径向蠕应变均先增加后减小;当恒载应力小于51 MPa时,试样体积压缩, Kh-z在±0.28%范围内,表明轴向蠕变与径向蠕变效应彼此相当;当超过该应力水平后,试样扩容,Kz和Kh剧增,Kh-z由0.21%突增至2.64%,在试样发生蠕变破坏时达到峰值,表明与轴向蠕变相比,在扩容阶段径向蠕变效应更加明显。选用西原体模型来描述灰岩轴向蠕变特性,通过曲线拟合的最小二乘法求取蠕变模型参数,R2均值为0.931,拟合效果较好。

关键词: 岩石力学, 分级加载, 蠕变试验, 西原体模型

Abstract:

The uniaxial creep test with step loading is carried out for the deep limestone,the axial and radial creep strain of different stress levels are obtained.Based on the test results,the change laws of axial creep strain,radial crcep strain and volumetric strain under different stress levels are analyzed.In addition to,the ratios of the axial and radial creep strain to the total strain are studied,which are defined as the ratio of creep effect Kz and Kh,and the difference between those is Kh-z.The study found that with the increase of the stress level,the axial creep strain and radial creep strain increase first and then decrease.When the constant stress is less than 51 MPa,the sample volume is compressed, Kh-z are within the scope of ±0.28%.It shows that the axial creep effect and radial creep effect are equal.However,if the stress is exceeded,the sample will expand and kz,kh increase rapidly,kh-z increased from 0.21% to 2.64%.It will reach peak value when the creep failure of specimen occurs.The results show that the radial creep effect is more obvious in the expansion stage,compared with the axial creep.The fitting effect is better by describing the characteristics of limestone axial creep with visco-elastoplastic model,and use the method of least squares curve fitting to get the creep model parameters,the average value of  R2 is 0.931.

Key words: rock mechanics, step loading, creep experiment, visco-elastoplastic model

中图分类号: 

  • TD853

[1] Zhou Hongwei,Xie Heping,Zuo Jianping.Developments in researches on mechanical behaviors of rocks under the condition of high ground pressure in the depths[J].Advances in Mechanics,2005,35(1):91-99.[周宏伟,谢和平,左建平.深部高地应力下岩石力学行为研究进展[J].力学进展,2005,35(1):91-99.]
[2] Sun Jun.Rock rheological mechanics and its advance in engineering applications[J].Chinese Journal of Rock Mecha- nics and Engineering,2007,27(6):1081-1106.[孙钧.岩石流变力学及其工程应用研究的若干进展[J].岩石力学与工程学报,2007,27(6):1081-1106.]
[3] He Manchao,Lv Xiaojian,Jing Haihe.Characters of surrounding rock mass in deep engineering and its non-linear dynamic mechanical design concept[J].Chinese Journal of Rock Mec- hanics and Engineering,2002,21(8):1215-1224.[何满潮,吕晓俭,景海河.深部工程围岩特性及非线性动态力学设计理念[J].岩石力学与工程学报,2002,21(8):1215-1224.]
[4] Li Na,Cao Ping,Yi Yongliang,et al.Creep properties experiment and model of deep rock with step loading and unloading[J].Journal of Central South University(Science and Technology),2011,42(11):3465-3471.[李娜,曹平,衣永亮,等.分级加卸载下深部岩石流变实验及模型[J]. 中南大学学报(自然科学版),2011,42(11):3465-3471.]
[5]  Griggs D T.Creep of rocks[J].Journal of Geology,1939,47(3):225-251.
[6] Chen Zongji,Kang Wenfa.On the locked in stress,creep and dilatation of rocks,and the constitutive equations[J].Chinese Journal of Rock Mechanics and Engineering,1991,10(4):299-312.[陈宗基,康文法.岩石的封闭应力、蠕变和扩容及本构方程[J].岩石力学与工程学报,1991,10(4):299-312.]
[7] Han  Gengyou,Wang Sijing,Zhang Xiaoping,et al.Study of creep properties of thinly lam inated rock under step loading[J].Chinese Journal of Rock Mechanics and Engineering,2010,29(11):2239-2247.[韩庚友,王思敬,张晓平,等.分级加载下薄层状岩石蠕变特性研究[J].岩石力学与工程学报,2010,29(11):2239-2247.]
[8] Shao Zhushan,Li Xiaozhao.Research into properties of creep and damage in brittle rocks based on micromechanice[J].Chinese Journal of Solid Mechanics,2015,36(S1):44-49.[邵珠山,李晓照.基于细观力学的脆性岩石蠕变损伤特性研究[J].固体力学学报,2015,36(S1):44-49.]
[9] Liu Chuanxiao,Zhang Jiawang,He Jiadong,et al.Phase deformation and viscous properties in creep test for fine sandstone specimen[J].Mining & Metallurgy,2010,19(4):12-15,20.[刘传孝,张加旺,贺加栋,等.细砂岩阶段蠕应变特征与粘滞性试验研究[J].矿冶,2010,19(4):12-15,20.]
[10] Zhang Tiancai,Wan Ling.Experimental study on creep of rock salt[J].Mining Technology,2015,15(5):41-44.[张天才,万玲.岩盐蠕变的试验研究[J].采矿技术,2015,15(5):41-44.]
[11] Liu Chuanxiao,He Jiadong,Zhang Meizheng,et al.Longterm strength test and application of hard fine sandstone in deep site[J].Journal of Mining & Safety Engineering,2010,27(4):581-584.[刘传孝,贺加栋,张美政,等.深部坚硬细砂岩长期强度试验[J].采矿与安全工程学报,2010,27(4):581-584.]
[12] Yang Hongwei,Xu Jiang,Peng Shoujian,et al.Study of sandstone creep characteristics under stepwise loading pore water pressures[J].Rock and Soil Mechanics,2015,36(S2):365-370.[杨红伟,许江,彭守建,等.孔隙水压力分级加载砂岩蠕变特性研究[J].岩土力学,2015,36(增2):365-370.]
[13] Tao Bo,Wu Faquan,Guo Gaimei,et al.Flexibility of visco-elastoplastic model to rheological characteristics of rock and solution of rheological parameter[J].Chinese Jour- nal of Rock Mechanics and Engineering,2005,24(17):3165-3171.[陶波,伍法权,郭改梅,等.西原模型对岩石流变特性的适应性及其参数确定[J].岩石力学与工程学报,2005,24(17):3165-3171.]
[14] Gong Cong,Li Changhong,Zhao Kui.Acoustic emission characteristics during short-time creep process of red sandstone under different stress level[J].Journal of North- eastern University(Natural Science),2015,36(9):1347- 1352.[龚囱,李长洪,赵奎.不同应力水平下红砂岩短时蠕变声发射特征[J].东北大学学报(自然科学版),2015, 36(9):1347-1352.]
[15] Cai Meifeng.Rock Mechanics and Engineering[M].Beijing:Science Press,2002:212-215.[蔡美峰.岩石力学与工程[M].北京:科学出版社,2002:212-215.]
[16] Gong Cong.Study on the Acoustic Emission Characteristics During Red Sandstone Creep Failure Process under Step Load and Unload Tests[D].Beijing:University of Science and Technology Beijing,2015.[龚囱.分级加卸载条件下红砂岩蠕变破坏声发射特性研究[D].北京:北京科技大学,2015.]
[17] Li Qingqi.Curve fitting method for creep parameter of soft rock[J].Chinese Journal of Rock Mechanics and Engineering,1998,17(5):81-86.[李青麒.软岩蠕变参数的曲线拟合计算方法[J].岩石力学与工程学报,1998,17(5):81-86.]
[18] Zhang Guangcheng,Wang Wenjuan,Han Huilei.Nonlinear Optimization Method[M].Beijing:Higher Education Press,2005:120-166.[张光澄,王文娟,韩会磊.非线性最优化计算方法[M].北京:高等教育出版社,2005:120-166.]

[1] 史采星, 郭利杰, 李文臣, 张丹. 铅锌冶炼渣充填胶凝材料研究及应用[J]. 黄金科学技术, 2018, 26(2): 160-169.
[2] 刘定一, 王李管, 陈鑫, 钟德云, 徐志强. 地下矿中长期计划多目标优化及应用研究[J]. 黄金科学技术, 2018, 26(2): 228-233.
[3] 林格, 宫凤强. 不同受力维度下红砂岩失稳评判指标研究[J]. 黄金科学技术, 2018, 26(2): 195-202.
[4] 曹世荣,韩建文,李永欣,王晓军 *,冯萧,卓毓龙. 基于声发射概率密度函数固废胶结充填体损伤分析[J]. 黄金科学技术, 2017, 25(6): 92-98.
[5] 丁剑锋. 某金矿矿仓治理研究[J]. 黄金科学技术, 2017, 25(4): 52-57.
[6] 李宗楠,郭利杰*,余斌,史采星 . 基于宾汉姆体的高浓度尾砂浆剪切变稀规律研究[J]. 黄金科学技术, 2017, 25(4): 33-38.
[7] 白朝阳,王国伟,张鹏,刘拴平. 水平采空区群条件下矿柱回采爆破位置研究[J]. 黄金科学技术, 2017, 25(4): 81-86.
[8] 徐怀浩,李进友. 大尹格庄金矿磨矿系统增产降耗的应用实践[J]. 黄金科学技术, 2017, 25(3): 116-120.
[9] 王新民,荣帅,赵茂阳,张钦礼. 基于变权重理论和TOPSIS的尾砂浓密装置优选[J]. 黄金科学技术, 2017, 25(3): 77-83.
[10] 胡建华,杨春,周炳任,周科平,张绍国. 巷道压顶光面爆破裂隙扩展模拟及参数优化[J]. 黄金科学技术, 2017, 25(2): 45-53.
[11] 贾敏涛,汪群芳,吴冷峻. 深部开采热环境控制技术研究现状及展望[J]. 黄金科学技术, 2017, 25(2): 83-88.
[12] 刘志祥,龚永超,李夕兵. 基于分形理论和BP神经网络的充填料性能研究[J]. 黄金科学技术, 2017, 25(2): 38-44.
[13] 曹世荣,韩建文,肖伟晶,卓毓龙,王晓军,冯萧. 不同骨料含量胶结充填体的应力—应变关系研究[J]. 黄金科学技术, 2017, 25(1): 93-98.
[14] 赵国彦,侯俊,张小瑞,李地元,王涛. 磷石膏膏体充填体力学特性研究[J]. 黄金科学技术, 2016, 24(5): 7-12.
[15] 王新民,樊彪,张德明,李帅. 基于AHP和TOPSIS的充填方案综合评判优选[J]. 黄金科学技术, 2016, 24(5): 1-6.
Viewed
Full text


Abstract

Cited

  Shared   
  Discussed   
No Suggested Reading articles found!