Feasibility Study of Flash Flotation of a Gold Mine in Plateau Area of Qinghai Province
Received date: 2017-06-28
Revised date: 2017-08-11
Online published: 2018-02-12
The raw ore of a gold mine in plateau area of Qinghai Province belongs to fine grained altered rock type，the recovery rate of flotation is low.By adjusting the flotation process parameters，the flotation effect has not been significantly improved.Through investigation of grading classification process and analysis of hydrocyclone’s underflow size sieve，it is found that the classification efficiency of hydrocyclone is 43%~ 60%，and the phenomenon of “anti-enrichment” exist in the underflow，in which the gold content of some particles reached above 20×10-6.Those useful minerals of monomeric dissociation were circulated in closed circuit process and easily causing overgrinding and slime encapsulation，which limited the flotability of useful minerals，so the recovery rate is difficult to effectively enhance.The simulation of manufacturing process was conducted in laboratory，by increasing flash flotation operation at the underflow of a hydrocyclone，the yield of concentrate in flash flotation reached 4.07%，and the grade of gold in concentrate reached 38.31×10-6.The useful mineral of monomeric dissociation in the underflow of a hydrocyclone has been collected by the flash flotation to achieve the effect of “early and quick collection”，reducing the probability of overgrinding and slime encapsulation of these useful minerals.The overflow continued to be ground to the required fineness to carry out closed-circuit test of routine flotation，and the comprehensive recovery of gold was increased from 80.90% under the conventional flotation process to 83.96%.
LI Fei , CHEN Ziqiang . Feasibility Study of Flash Flotation of a Gold Mine in Plateau Area of Qinghai Province[J]. Gold Science and Technology, 2017 , 25(5) : 80 -84 . DOI: 10.11872/j.issn.1005-2518.2017.05.080
［1］ Tang Wengang.Basic Theory of Hydrocyclone and Its Applied Research［D］.Chongqing：Chongqing University，2006.［唐文钢.水力旋流器的基础理论及其应用研究［D］.重庆：重庆大学，2006.］
［2］ Wang Panzhi.Selection method of flash flotation machine in gold mine［J］.Industrial B，2015，57 （5）： 259.［王攀志.黄金矿山闪速浮选机的选择方法［J］.工业B，2015，57（5）：259.］
［3］ Peng Yuanlun.Study on the test of coarse particle flash flotation［C］//Proceedings of the Conference on the Exploitation and Utilization of Mineral Resources in Western China.Beijing：Mining and Metallurgy，2002：154-156.［彭远伦.粗粒闪速浮选试验研究［C］//西部矿产资源开发利用与保护学术会议论文集.北京：矿冶，2002：154-156.］
［4］ He Congxing.Coarse particle flash flotation：The effective way to improve floatation index［J］.Nonferrous Metallurgy，1988（3）：17-19.［何从行.粗粒闪速浮选——提高浮选指标的有效途径［J］.有色矿冶，1988（3）：17-19.］
［5］ Zhang Xinkuan，Li Hong.The industrial experiments of flash flotation in Jilongshan gold mine and the feasibility analysis of application［J］.China Mine Engineering，1998（4）：37-41.［张新宽，李宏.闪速浮选在鸡笼山金矿的工业试验及应用可行性分析［J］.中国矿山工程，1998（4）：37-41.］
［6］ Yao Mingzhao，Li Qiang，Zhang Yuejun，et al.Development and application of high concentration flotation technology［J］.Modern Mining，2016（4）：75-77.［姚明钊，李强，张跃军，等.高浓度浮选技术的发展与应用［J］.现代矿业，2016（4）：75-77.］
［7］ Wang Hairui.Flash flotation process and its application［C］// National Powdery Engineering Academic Conference.Beijing：The Chinese Society for Metals，1998.［王海瑞.闪速浮选工艺及其应用［C］//全国粉体工程学术会议.北京：中国金属学会，1998.］
［8］ Zheng Xuehua.Kinetics Research of Flash Flotation Separation on Copyrite and Pyrite［D］.Ganzhou：Jiangxi University of Technology，2015.［郑雪华.黄铜矿、黄铁矿快速浮选分离动力学研究［D］.赣州：江西理工大学，2015.］
［9］ Ming Pingtian，Wu Guomin，Li Fei，et al.Research on process investigation and analysis of grinding classification［J］.Non-ferrous Metals（Mineral Processing Section），2012（6）：45- 48.［明平田，吴国民，李飞，等.磨矿分级工艺考察及分析研究［J］.有色金属（选矿部分），2012（6）：45-48.］
［10］ Liu Yongqiang.Research on the Flotation Method of Swirling Flow［D］.Beijing：Beijing Institute of Metallurgical Research，1996.［刘永强.旋流闪速浮选法的研究［D］.北京：北京矿冶研究总院，1996.］
［11］ Li Changgen，Liu Yongqiang.Study on cyclone flash flotationⅠ.Feasibility study on cyclone flash flotation［J］.Nonferrous Metal Engineering，2000，52（1）：25-32.［李长根，刘永强.旋流闪速浮选法的研究──Ⅰ.旋流闪速浮选法的可行性研究［J］.有色金属工程，2000，52（1）：25-32.］
［12］ Wang Zheng，Wei Li.Using SPSS software achieve pharmacy experiment orthogonal design’s variance analysis［J］.Journal of Mathematical Medicine，2014（1）：99-102.［王政，魏莉.利用 SPSS 软件实现药学实验中正交设计的方差分析［J］.数理医药学杂志，2014（1）：99-102.］
［13］ Zhu Hongbing，Xi Kaiqiang.The orthogonal experimental design in SPSS 17.0 and data analysis［J］.Journal of Capital University of Physical Education and Sports，2013，25（3）：283-288.［朱红兵，席凯强.SPSS 17.0中的正交试验设计与数据分析［J］.首都体育学院学报，2013，25（3）：283-288.］
［14］ Liao Qinhuan.Application of flash flotation in a certain gold mine concentrator in Gansu Province［J］.Gold Science and Technology，2016，24（2）：108-111.［廖钦桓.闪速浮选工艺在甘肃某金矿选矿厂的应用［J］.黄金科学技术，2016，24（2）：108-111.］
［15］ Tan Ming，Feng Tianran，Han Zhibin，et al.Industrial test study on performance of YXⅡ-4 flash flotation cell in the milling-classification circuit［J］.Nonferrous Metals（Mineral Processing Section），2017（1）：74-77.［谭明，冯天然，韩志彬，等.YXⅡ-4闪速浮选机在磨矿分级回路的工业试验研究［J］.有色金属（选矿部分），2017（1）：74-77.］
［16］ Huang Kaiguo.The progress and application of branch flotation［J］.Nonferrous Metals（Mineral Processing Section），1991（2）：22-28. ［黄开国.分支浮选的进展及应用［J］.有色金属（选矿部分），1991（2）：22-28.］
［17］ Wang Yanhui，Shi Fengye，Zhao Jianwei，et al.Application of stage grinding and stage flotation process in Yunnan Zhenyuan gold mine［J］.Gold，2013，34（9）：62-64.［王彦慧，石凤野，赵健伟，等.阶段磨矿阶段浮选工艺在云南镇沅金矿的应用［J］.黄金，2013，34（9）：62-64.］
/
| 〈 |
|
〉 |
甘公网安备 62010202000672号