[an error occurred while processing this directive] [an error occurred while processing this directive] [an error occurred while processing this directive]
[an error occurred while processing this directive]

Gold Science and Technology >

2022 , Vol. 30 >Issue 1: 64 - 71

DOI: https://doi.org/10.11872/j.issn.1005-2518.2022.01.124

Mining Technology and Mine Management

Study on the Effect of Physical Properties of Full Tailings on Flocculation and Sedimentation Performance

  • Zhaoyu LI , 1, 2 ,
  • Wei SUN , 1, 2 ,
  • Shengyou ZHANG 1, 2 ,
  • Jinxin LI 1, 2
Expand
  • 1. Faculty of Land and Resources Engineering, Kunming University of Science and Technology, Kunming 650093, Yunnan, China
  • 2. Yunnan Key Laboratory of Sino-German Blue Mining and Utilization of Special Underground Space, Kunming 650093, Yunnan, China

Received date: 2021-09-06

  Revised date: 2021-11-18

  Online published: 2022-04-25

Fold

Highlights

With the depletion of shallow mineral resources and the implementation of the national environmental protection policy，the filling mining method has gradually become the preferred mining method for major mines.In order to study the influence of the tailings own characteristics on the performance of flocculation and settlement during the filling process，the influence of the tailings own physical characteristics on the settlement effect was investigated by conducting flocculation and settlement experiments on four different tailings at the same feeding concentration，flocculant type and dosage.The experimental results and regression analysis show that the specific gravity，median particle size and -200 mesh particle content of the tailing sand are not mono-tonically correlated with the settling velocity and bottom flow concentration，and there is no simple univariate correlation between them，and the fitted equations are not well fitted by non-linear regression.The median particle size of the tailing sand show a positive correlation with the settling velocity and the bottom flow concentration.The -200 mesh particle content is negatively correlated with the settling velocity and bottom flow concentration in the process of flocculation and settling，and the fit is high，which has a higher degree of influence on the settling effect.The single-factor correlation of specific gravity of tailings，median particle size with settling velocity and bottom flow concentration is low，and the regression equation of these three factors with settling velocity and bottom flow concentration is obtained by multiple linear regression using SPSS software，and the significance of these factors is further analyzed.For the influence degree of flocculation settling velocity of tailings mortar，-200 mesh particle content > median particle size > proportion of the tailings.For the influence degree of tailings bottom flow concentration，median particle size >-200 mesh particle con-tent > proportion of the tailings.

Cite this article

Zhaoyu LI , Wei SUN , Shengyou ZHANG , Jinxin LI . Study on the Effect of Physical Properties of Full Tailings on Flocculation and Sedimentation Performance[J]. Gold Science and Technology, 2022 , 30(1) : 64 -71 . DOI: 10.11872/j.issn.1005-2518.2022.01.124

[an error occurred while processing this directive]

http://www.goldsci.ac.cn/article/2022/1005-2518/1005-2518-2022-30-1-64.shtml

References

Publishing order | Descend order by publishing year | Descend order by cited within
Fan Y P， Ma X M， Dong X S， al et，2020，Characterisation of floc size，effective density and sedimentation under various flocculation mechanisms［J］.Water Science and Technology：A journal of the International Association on Water Pollution Research，82（7）：1261-1271.

Guo Jiabin， Wang Hongjiang， Tian Zhigang， al et，2021.Effect of different types of flocculant on the thickening property of superfine tailings［J］.Mining Research and Development，41（4）：141-145.

Jiao Huazhe， Wang Hongjiang， Wu Aixiang， al et，2010.Rule and mechanism of flocculation sedimentation of unclassified tailings［J］.Journal of University of Science and Technology Beijing，32（6）：702-707.

Kang Qian， Wang Yunmin， He Yan， al et，2019.Experimental study on continuous settlement law under solid-liquid two phase coupling conditions of unclassified tailings［J］.Gold Science and Technology，27（6）：896-902.

Li Jinxin， Sun Wei， Zhang Shengyou， al et，2021.Factors influencing flocculation and sedimentation of full tailings ［J］.Journal of Kunming University of Science and Technology（Natural Science），46（1）：45-53.

Liu Qi， Cen Youhua， Liu Dongrui， al et，2021.Prediction of technical parameters of full tailings thickening based on static settlement test ［J］.Gold Science and Technology，29（2）：266-274.

Liu Qi， Cen Youhua， Tang Mingdong， al et，2021.Influence of different physical properties of tailings on thickening performance［J］.Mining Research and Development，41（5）：124-130.

Niu Peng， Wang Hongjiang， Wu Aixiang， al et，2019.Static flocculation and sedimentation rule of ultrafine whole tailings and its application in design of vertical sand bin［J］.Industrial Minerals & Processing，48（3）：35-39，46.

Shi Xiuzhi， Hu Haiyan， Du Xianghong， al et，2010.Experimental study on flocculating sedimentation of tailings slurry in a vertical sand tank［J］.Mining and Metallurgical Engineering，30（3）：1-3，11.

Sui Can， Wang Xiaojun， Wang Xinmin， al et，2020.Study on the flocculation law and mechanism of APAM unit consumption to different particle size in the flocculation and sedimentation of tailings［J］.Mining Research and Development，40（5）：67-74.

Sun Hao， Li Maolin， Cui Rui， al et，2021.Influence of different flocculants on settling effect of lead-zinc tailings ［J］.Conservation and Utilization of Mineral Resources，41（1）：66-72.

Wang Guilian，2007.Study on the design of experiments for measuring liquid viscosity by Stokes method ［J］.Medical Information，（3）：408-409.

Wang S， Song X P， Wang X J， al et，2020.Influence of coarse tailings on flocculation settlement［J］.International Journal of Minerals，Metallurgy and Materials，27（8）：1065-1074.

Wang X M， Zhao B， Zhang Q L， al et，2008.Cemented backfilling technology with unclassified tailings based on vertical sand silo［J］.Journal of Central South University of Technology，15（6）：801-807.

Wang Xing， Qu Yuanyuan， Hu Weiwei， al et，2008.Experimental research on factors influencing tailing pulp flocculation on settling［J］.Metal Mine，37（5）：149-151，153.

Wu Aixiang， Zhou Jing， Yin Shenghua， al et，2016.Influence factors on flocculation sedimentation of unclassified tailings［J］.The Chinese Journal of Nonferrous Metals，26（2）：439-446.

Zhang Meidao， Rao Yunzhang， Xu Wenfeng， al et，2020.Experimental study on static flocculation and settlement of full tailing mortar in a mine［J］.Metal Mine，49（12）：50-54.

Zheng Bokun， Deng Gaoling， Li Xiangdong，2018.Research on the application of long distance and stable pressure paste filling technology in high and steep mountainous areas ［J］.Mining Technology，18（2）：1-2，14.

Zhu Jianguo， Liu Fuchun， Xiong Youwei， al et，2020.Experimental study on settling characteristics of tail sand with different grain size grading［J］.Mining Research and Development，40（5）：41-44.

Zhu Z F， Xiong X Z， Liang C H， al et，2018.On the flocculation and settling characteristics of low- and high-concentration sediment suspensions：Effects of particle concentration and salinity conditions［J］.Environmental Science and Pollution Research，25（14）：14226-14243.

郭佳宾，王洪江，田志刚，等，2021.不同类型絮凝剂对超细尾砂浓密性能的影响［J］.矿业研究与开发，41（4）：141-145.

焦华喆，王洪江，吴爱祥，等，2010.全尾砂絮凝沉降规律及其机理［J］.北京科技大学学报，32（6）：702-707.

康虔，王运敏，贺严，等，2019.固液两相耦合条件下全尾砂连续沉降规律研究［J］.黄金科学技术，27（6）：896-902.

李金鑫，孙伟，张盛友，等，2021.全尾砂絮凝沉降影响因素研究［J］.昆明理工大学学报（自然科学版），46（1）：45-53.

刘奇，岑佑华，刘东锐，等，2021.基于静态沉降试验的全尾砂浓密技术参数预测［J］.黄金科学技术，29（2）：266-274.

刘奇，岑佑华，唐鸣东，等，2021.不同尾砂物理性质对尾砂浓密性能的影响［J］.矿业研究与开发，41（5）：124-130.

牛鹏，王洪江，吴爱祥，等，2019.超细全尾砂静态絮凝沉降规律及其在立式砂仓设计中的应用［J］.化工矿物与加工，48（3）：35-39，46.

史秀志，胡海燕，杜向红，等，2010.立式砂仓尾砂浆液絮凝沉降试验研究［J］.矿冶工程，30（3）：1-3，11.

隋璨，王晓军，王新民，等，2020.全尾砂絮凝沉降中APAM单耗对不同粒级颗粒絮凝作用规律及机理研究［J］.矿业研究与开发，40（5）：67-74.

孙浩，李茂林，崔瑞，等，2021.不同絮凝剂对铅锌尾矿沉降效果的影响［J］.矿产保护与利用，41（1）：66-72.

王桂连，2007.斯托克斯法测量液体黏度设计实验的研究［J］.医学信息，（3）：408-409.

王星，瞿圆媛，胡伟伟，等，2008.尾矿浆絮凝沉降影响因素的试验研究［J］.金属矿山，37（5）：149-151，153.

吴爱祥，周靓，尹升华，等，2016.全尾砂絮凝沉降的影响因素［J］.中国有色金属学报，26（2）：439-446.

张美道，饶运章，徐文峰，等，2020.某矿全尾砂浆静态絮凝沉降试验研究［J］.金属矿山，49（12）：50-54.

郑伯坤，邓高岭，李向东，2018.高陡山区长距离稳压膏体充填技术应用研究［J］.采矿技术，18（2）：1-2，14.

朱建国，刘福春，熊有为，等，2020.不同粒径级配尾砂沉降特性的试验研究［J］.矿业研究与开发，40（5）：41-44.

Options
Outlines

/

〈 〉

[an error occurred while processing this directive]