Research on Mechanical and Energy Dissipation Characteristics of Red Sandstone in SHPB Compression Test

Jian HU; Fengqiang GONG; Hangyu JIA

doi:10.11872/j.issn.1005-2518.2020.03.008

Gold Science and Technology >

2020 , Vol. 28 >Issue 3: 411 - 420

DOI: https://doi.org/10.11872/j.issn.1005-2518.2020.03.008

Mining Technology and Mine Management

Research on Mechanical and Energy Dissipation Characteristics of Red Sandstone in SHPB Compression Test

Jian HU ^,¹ ,
Fengqiang GONG ^,¹^,² ,
Hangyu JIA ¹

Expand

^1. School of Resources and Safety Engineering，Central South University，Changsha 410083，Hunan，China
^2. School of Civil Engineering，Southeast University，Nanjing 211189，Jiangsu，China

Received date: 2019-12-18

Revised date: 2020-02-21

Online published: 2020-07-01

Fold

Highlights

In underground engineering，rock （body） is damaged or destroyed by impact drilling，blasting，crushing and other dynamic disturbance.In this process，external energy conversion and internal energy consumption are inevitable.Energy dissipation is an important factor that causes rock damage and failure state，so it is of great significance to study the dynamic mechanical properties and failure behavior of rock from the perspective of energy. At present，in the research of rock dynamic characteristics，the commonly used equipment are drop hammer，split Hopkinson pressure bar （SHPB） and light gas gun，among which the SHPB test system is generally used to study the dynamic characteristics of rock under medium and high strain rate（10~10³s^-1）.In order to quantitatively describe the energy dissipation capacity of rock in the process of dynamic compression，the uniaxial dynamic compression tests of cylindrical red sandstone specimens were carried out with SHPB device，and the failure process of the specimen was recorded by a high-speed camera.The test results show that with the increase of incident energy，the specimen shows three different states：intact，ruptured and broken after the dynamic impact loads，and the peak stress of specimen shows obvious strain rate effect.In addition，the failure mode of specimens is mainly tensile failure.In the aspect of energy consumption，the dissipative energy of the specimen shows a two-stage linear growth rule with the critical incident energy as the interval point.When the incident energy is less than the critical incident energy，the specimen remains intact after impact.When the incident energy is greater than the critical incident energy，the specimen will be broken after impact and the fragments will fly out.Based on the obtained linear energy consumption rule，two stages of dynamic compression energy dissipation coefficient （DCEDC） are defined respectively.When the specimen is in intact state，the ideal DCEDC is a fixed value，for the red sandstone specimen in this paper，this value is 0.19. When the specimen is in the broken state the DCEDC increases with the increasing incident energy and gradually approaches 0.68.

Cite this article

Jian HU , Fengqiang GONG , Hangyu JIA . Research on Mechanical and Energy Dissipation Characteristics of Red Sandstone in SHPB Compression Test[J]. Gold Science and Technology, 2020 , 28(3) : 411 -420 . DOI: 10.11872/j.issn.1005-2518.2020.03.008

[an error occurred while processing this directive]

http://www.goldsci.ac.cn/article/2020/1005-2518/1005-2518-2020-28-3-411.shtml

References

Publishing order | Descend order by publishing year | Descend order by cited within

1	Bernabé Y， Revil A.Pore-scale heterogeneity，energy dissipation and the transport properties of rocks[J].Geophy-sical Research Letters，1995，22（12）：1529-1532.

2	Sujatha V， Kishen J M C.Energy release rate due to friction at bimaterial interface in dams[J].Journal of Engineering Mechanics，2003，129（7）：793-800.

3	Ju Y， Wang H J， Yang Y M，et al.Numerical simulation of mechanisms of deformation，failure and energy dissipation in porous rock media subjected to wave stresses[J].Science China Technological Sciences，2010，53（4）：1098-1113.

4	Peng R， Ju Y， Wang J G，et al.Energy dissipation and release during coal failure under conventional triaxial compression[J].Rock Mechanics and Rock Engineering，2015，48（2）：509-526.

5	Xie H P， Li L Y， Peng R D，et al.Energy analysis and criteria for structural failure of rocks[J].Journal of Rock Mechanics and Geotechnical Engineering，2009，1（1）：11-20.

6	Xie H P， Li L Y， Ju Y，et al.Energy analysis for damage and catastrophic failure of rocks[J].Science China Technological Sciences，2011，54（Supp.1）：199-209.

宫凤强，闫景一，李夕兵.基于线性储能规律和剩余弹性能指数的岩爆倾向性判据[J].岩石力学与工程学报，2018，37（9）：1993-2014.

Gong

Fengqiang

， Yan

Jingyi

， Li

Xibing

.A new criterion of rock burst proneness based on the linear energy storage law and the residual elastic energy index[J].Chinese Journal of Rock Mechanics and Engineering，2018，37（9）：1993-2014.

8	宫凤强，罗松，李夕兵，等.红砂岩张拉破坏过程中的线性储能和耗能规律[J].岩石力学与工程学报，2018，37（2）：352-363. Gong Fengqiang， Luo Song， Li Xibing，et al.Linear energy storage and dissipation rule of red sandstone materials during the tensile failure process[J].Chinese Journal of Rock Mechanics and Engineering，2018，37（2）：352-363.

9	Zhou Y X， Xia K， Li X B，et al.Suggested methods for determining the dynamic strength parameters and mode-I fracture toughness of rock materials[J].International Jour-nal of Rock Mechanics and Mining Sciences，2012，49：105-112.

10	Kumar A.The effect of stress rate and temperature on the strength of basalt and granite[J].Geophysics，1968，33（3）：501-510.

11	Lok T S， Li X B， Liu D，et al.Testing and response large diameter brittle materials subjected to high strain rate[J].Journal of Materials in Civil Engineering，2002，14（3）：262-269.

12	Li J C， Ma G W.Experimental study of stress wave propagation across a filled rock joint[J].International Journal of Rock Mechanics and Mining Sciences，2009，46（3）：471-478.

13	Zhu J B， Zhao X B， Li J C，et al.Normally incident wave transmission across one joint set with virtual wave source method[J].Journal of Applied Geophysics，2011，73：283-288.

14	宫凤强.动静组合加载下岩石力学特性和动态强度准则的试验研究 [D].长沙：中南大学，2010. Gong Fengqiang.Experimental Study of Rock Mechanical Properties Under Coupled Static-dynamic Loads and Dynamic Strength Criterion[D].Changsha：Central South University，2010.

15	Gong F Q， Zhao G F.Dynamic indirect tensile strength of sandstone under different loading rates[J].Rock Mechanics and Rock Engineering，2014，47（6）：2271-2278.

16	Zhang Q B， Zhao J.A review of dynamic experimental techniques and mechanical behaviour of rock materials[J].Rock Mechanics and Rock Engineering，2014，47（4）：1411-1478.

17	单仁亮，陈石林，李宝强.花岗岩单轴冲击全程本构特性的实验研究[J].爆炸与冲击，2000，20（1）：32-38. Shan Renliang， Chen Shilin， Li Baoqiang.Experimental study of granite constitutive properties under uniaxial impact[J].Explosion and Shock Waves，2000，20（1）：32-38.

18	刘军忠，许金余，吕晓聪，等.冲击压缩荷载下角闪岩的动态力学性能试验研究[J].岩石力学与工程学报，2009，28（10）：2113-2120. Liu Junzhong， Xu Jinyu， Xiaocong Lü，et al.Experimental study on dynamic mechanical properties of Amphibolies under impact compressive loading[J].Chinese Journal of Rock Mechanics and Engineering，2009，28（10）：2113-2120.

19	翟越，马国伟，赵均海，等.花岗岩和混凝土在单轴冲击压缩荷载下的动态性能比较[J].岩石力学与工程学报，2007，26（4）：762-768. Zhai Yue， Ma Guowei， Zhao Junhai，et al.Comparison of dynamic capabilities of granite and concrete under uniaxial impact compressive loading[J].Chinese Journal of Rock Mechanics and Engineering，2007，26（4）：762-768.

20	Li X B， Lok TS， Zhao J.Dynamic characteristics of granite subjected to intermediate loading rate[J].Rock Mechanics and Rock Engineering，2005，38（1）：21-39.

21	Hong L， Zhou Z， Yin T，et al.Energy consumption in rock fragmentation at intermediate strain rate[J].Journal of Central South University of Technology，2009，16（4）：677-682.

22	Lundberg B.A split Hopkinson bar study of energy absorption in dynamic rock fragmentation[J].International Journal of Rock Mechanics and Mining Sciences & Geomechanics Abstracts，1976，13（6）：187-197.

23	Gong F Q， Si X F， Li X B，et al.Dynamic triaxial compression tests on sandstone at high strain rates and low confining pressures with split Hopkinson pressure bar[J].International Journal of Rock Mechanics and Mining Science，2019，113：211-219.

24	Gong F Q， Yan J Y， Luo S，et al.Investigation on the linear energy storage and dissipation laws of rock materials under uniaxial compression[J].Rock Mechanics and Rock Engineering，2019，52（11）：4237-4255.

Options

Outlines