img

QQ群聊

img

官方微信

高级检索

黄金科学技术 ›› 2016, Vol. 24 ›› Issue (1): 92-96.doi: 10.11872/j.issn.1005-2518.2016.01.092

• 采选技术与矿山管理 • 上一篇    下一篇

抱伦金矿通风系统优化研究

李刚1,2,3,吴超1   

  1. 1.中南大学资源与安全工程学院,湖南  长沙   410083;
    2.中钢集团马鞍山矿山研究院有限公司,安徽  马鞍山   243000;
    3.金属矿山安全与健康国家重点实验室,安徽  马鞍山   243000
  • 收稿日期:2015-05-05 修回日期:2015-06-18 出版日期:2016-02-29 发布日期:2016-04-05
  • 作者简介:李刚(1982-),男,湖南衡阳人,博士研究生,高级工程师,从事矿井通风与除尘等方面的设计与科研工作。hunankedaligang@163.com
  • 基金资助:

    国家重点基础研究发展计划(“973”计划)项目“极端环境矿岩灾害机制研究”(编号:2012CB724207)和马鞍山科技计划项目“旋转射流帷幕雾化除尘器的研制”(编号:JN-2014-02)联合资助

Study on Optimization of Ventilation System in Baolun Gold Mine

LI Gang1,2,3,WU Chao1   

  1. 1.School of Resources and Safety Engineering,Central South University,Changsha   410083,Hunan,China;
    2.Sinosteel Maanshan Institute of Mining Research Co.,Ltd.,Maanshan   243000,Anhui,China;
    3.State Key Laboratory of Safety and Health for Metal Mine,Maanshan   243000,Anhui,China
  • Received:2015-05-05 Revised:2015-06-18 Online:2016-02-29 Published:2016-04-05

摘要:

为了改善井下环境、确保矿井生产安全,通风系统必须保持最佳运行状态。以抱伦金矿矿井通风系统为研究对象,通过对通风系统进行调查与测定,得出该矿通风系统存在矿井总风量不足、采区通风困难、机站风机效率低及采空区漏风严重等问题,井下通风系统运行受到干扰,严重影响了井下安全生产。利用计算机模拟解算优化分析,对该矿通风系统进行优化改造,提出了通风系统优化研究方案。现场实施结果表明:优化后的矿井通风系统通风效果明显改善,矿井总风量明显增加,机站效率为83.1%,风速合格率为87.5%,有效风量率为73.7%,采掘面平均温度为26.3 ℃。该优化方案改善了井下通风条件,解决了抱伦金矿现有通风系统存在的问题。

关键词: 矿井通风, 通风系统优化, 网络解算, 方案优选, 安全生产

Abstract:

In order to improve the bad mine circumstance and ensure the safety of the mine production,the ventilation system must maintain the best operating status.It takes the ventilation system in Baolun gold mine as the study subject,through the investigation and determination of the ventilation system,the problems existing in the underground ventilation system are as follows: the total air volume is insufficient,poor stope ventilation,low efficiency of the main fan,a large amount of air leakage in the mined area,etc.The underground ventilation system was severely disrupted,which seriously influenced the safety in production.Through computer networks resolving and optimization analysis,the ventilation system is optimized and the optimization scheme is put forward.The results show that the effect of optimized mine ventilation system is obviously enhanced,and the total air volume of mine is obviously increased.The fan station efficiency is 83.1%,the compliance of wind speed is 87.5%,the effective air volume rate is 73.7%,and the average temperature of mining surface is 26.3 ℃.The optimization scheme improves the underground ventilation conditions and solves the existing problems of the ventilation system in Baolun gold mine.

Key words: mine ventilation, ventilation system optimization, network calculation, scheme optimization, safety in production

中图分类号: 

  • TD724

[1]  赵千里,刘剑.用矿井通风仿真系统(MVSS)确定通风系统优化改造方案[J].中国安全科学学报,2002,12(2):14-18.
[3] 张发涛,蒋仲安,焦向东.基于AHP-FPR模型的矿井通风系统优化方案评价[J].中国安全生产科学技术,2012,8(10):125-130.
[4] 王英敏.矿井通风与防尘[M].北京:冶金工业出版社,1993.
[5] 付贵.矿井通风系统分析与优化[M].北京:机械工业出版社,1995.
[6] 孙英.近十年我国金属矿山通风系统的技术改造[J].金属矿山,1994,(5):25-29.
[7] 周心权.我国矿井环境模拟和控制技术的研究进展[J].中国安全科学学报,1993,(l):1-6.
[8] 吴国珉.典型有色金属矿山矿井通风系统优化与防尘技术研究[D].长沙:中南大学,2008.
[9] 康宝伟,王贻明,吴爱祥,等.某矿深部开拓复杂通风系统优化[J].矿业研究与开发,2013,33(1):80-83.
[10] 张伟,牛国庆,沈五名.庇山矿通风系统优化改造[J].工业安全与环保,2012,38(11):60-62.
[11] 陶树银,熊正明,程哲,等.金属矿山矿井通风系统优化研究[J].矿业研究与开发,2012,32(2):58-60.
[12] 吴冷峻,祝怡斌,王永生.韦岗铁矿通风系统改造[J].金属矿山,2002,(7):38-40.
[13] 梁超,扈守全.阜山金矿通风系统优化改造方案研究[J].中国矿业,2013,22(12):124-126.
[14] 王海宁,彭斌,彭家兰,等.大型复杂矿井通风系统的共性问题分析与优化实践[J].安全与环境学报,2014,14(3):24-27.
[15] 刘成敏,刘红芳,王海宁,等.某矿井通风系统优化及其可视化模型的构建[J].中国安全生产科学技术,2014,10(9):89-94.

[1] 王卫华,李坤,严哲,唐修 . 节理压缩闭合试验前后表面形态特征变化分析[J]. 黄金科学技术, 2016, 24(6): 84-89.
[2] 胡汉华,余斌斌. 控制循环风流新方法研究[J]. 黄金科学技术, 2016, 24(5): 61-66.
[3] 黄寿元,蔡建华,李刚. 沃溪坑口千米深井降温技术研究与实践[J]. 黄金科学技术, 2016, 24(3): 81-86.
[4] 袁风传,王楠. 山东石城矿区通风系统的建立及其应用效果[J]. J4, 2011, 19(2): 81-82.
[5] 王波 ,陈宝智 ,陈喜山 ,董金魁. 排风侧分区多级机站通风系统的应用实践[J]. J4, 2008, 16(4): 62-65.
[6] 许向东, 段拾山. 鸡冠嘴矿区通风系统技术改造可行性研究[J]. J4, 2005, 13(1-2): 91-96.
Viewed
Full text


Abstract

Cited

  Shared   
  Discussed   
No Suggested Reading articles found!